Article

MARS-Report: Paltry PPU position predictor


by The Nautical Insitute - published on 18 August 2023 803 -

MARS-Report 202332 - Courtesy "The Nautical Institute"

In darkness and with visibility further reduced to about 150m in fog, a container vessel was being brought to a tidal river berth under pilotage.

To monitor the vessel’s progress, the pilot had set up his portable pilotage unit (PPU). He had connected the rate-of-turn generator to the vessel’s pilot plug and had set a variable range marker on the radar with a radius of 0.5 nm. The PPU had a predictor that continually self-updated to display the vessel’s next six predicted positions at intervals of 30 seconds.

The pilot and the Master had exchanged their respective information; the passage plan, local traffic and berthing procedure (pilot) and the vessel’s condition and manoeuvring data (Master). The pilot increased the vessel’s speed in order to overcome cross-currents at the mouth of the river and then commenced a starboard turn to enter the river as normal. Soon, the vessel’s speed was about 16 knots. At this point, the Master was using the ECDIS located at the starboard conning position to monitor the vessel’s progress, while the OOW was using a paper chart.

At 2150, the pilot ordered half ahead. About two minutes later the pilot ordered 15 degrees of starboard helm to initiate the turn through the next bend in the river. He then used the predictor to assess the vessel’s rate of turn. Soon he ordered the rudder angle to be reduced to 10 degrees to starboard, then to 5 degrees and finally to midships.

At 2153:20 the vessel’s speed was near 14 knots and the rate of turn was about 25 degrees/minute to starboard. About a minute later, with the speed now 13 knots, the pilot cross-checked information from the PPU predictor with the radar. The radar information showed the vessel was not proceeding as indicated on the PPU so he ordered counter rudder to port and full ahead on the engine to stop the turn to starboard and correct the vessel’s position in the channel. This action was insufficient and the vessel grounded at 2156, within the navigable channel but in an area where silting had been reported and that the pilot knew was present. With the rising tide the team were able to re-float and dock the vessel about two hours later.

The official investigation found, among other things, that;
  • The pilot’s PPU was obtaining information from the vessel’s AIS, which was subject to GPS ‘smoothing’. As a result, the predicted vessel positions displayed on the PPU were not accurately reflecting the vessel’s future positions, but the pilot was unaware of this. Also,
  • The pilot did not inform the bridge team about the extent of silting within the navigable channel nor had the bridge team taken steps to obtain this information. As such, the bridge team was unable to identify or to assist the pilot in resolving the developing unsafe situation

Lessons Learned

  • Had the pilot used an independent DGPS antenna for his PPU the predicted positions would probably have been more accurate than those represented by the vessel’s AIS pilot plug.
  • Communication and planning is everything! The silting in the channel was not communicated to the bridge team by the pilot – but neither did the vessel’s team take the time to research this fact which was readily available via on-line sources.
  • Speed changes everything! In this case the vessel was proceeding at near 13 knots (6.68m/sec) in a narrow channel in near zero visibility. Proceeding at nine knots (4.63m/sec) would have given them extra time, about one minute, to reevaluate the circumstances and manoeuvre. This would likely have prevented the grounding

Join the conversation...

Login or register to write comments and join the discussion!
Captain Michael Schneider Lotsenbrüderschaft NOK I, Germany
on 27 August 2023, 10:10 UTC

May be better instead the use of PPU preductions for the intended turn ( GPS is always delayed compardr to gyro hesding!) would have been the proper use of the radar with Ecdis overlay and adjusted speed! Even good old paralle indexing using the range marker is helpful. Just doing same quite often on the Kiel Canal in dense fog and zero visibility. PPU for reference only, if necessary.
0

Read more...

Opinion Piloting, Autonomous Vessels, AI, and the coffee making machine

by Captain Ricardo Caballero "Themaritimepilot" - published on 15 June 2020

I am not a computer savvy. My knowledge in programming and robotics and those sort of things is nil. I get lost in the sea of social media and easily entangle myself in the web. All I have done for the last 25 years or so is to pilot ships through the Panama Canal. However, during the last couple of years I have done my best to catch up with technology, since it has enhanced our possibilities and improved safety in our field. But still, I have to admit that I am way behind the new guys in this important issue.

1

Video Fremantle Harbour Pilotage. Follow a Marine Pilot aboard a Containership.

published on 24 March 2021

Look at Pilotage: Containership under Pilotage into Fremantle Harbour, Western Australia.

0

Video Conti Stockholm - Pilotage Fremantle Harbour.

published on 24 March 2021

Conti Stockholm. PPU recording.
278m containership departing CT1 berth, Fremantle Harbour.
31/10/2020.

0

Video TV Interview Maritime Pilot Devan Pulliah

published on 11 July 2020

INTERVIEW ON MARITIME PILOTAGE..OPERATION FILMED WHILST CONDUCTING DOCKING OF OIL TANKER....

0

Video Berthing P02 skikda old port M/T duke1

published on 19 December 2019

Video was sent to Marine-Pilots.com by Mohamed Anwar Remichi

0

Article What is a Maritime Pilot? From "Crossing the Bar, The Adventures of a San Francisco Bay Bar Pilot" by Captain Paul Lobo

by Capt. Paul Lobo - published on 22 September 2020

Chapter 3 from the book "Crossing the Bar, The Adventures of a San Francisco Bay Bar Pilot" by Captain Paul Lobo, available on Amazon (link below)

1

Video 30 Days Timelapse at Sea | 4K | Through Thunderstorms, Torrential Rain & Busy Traffic

published on 6 July 2019

Follow my adventures on Instagram! http://instagram.com/Jeffrey.hk
30 Days of Timelapse, about 80,000 photos combined. 1500GB of Project files. Sailing in the open ocean is a unique feeling and experience.I hope to capture and share it for everyone to see.
Route was from Red Sea -- Gulf of Aden -- Indian Ocean -- Colombo -- Malacca Strait -- Singapore -- South East China Sea -- Hong Kong

1

Video History: Helicopter Transport Elbe River-Pilot (1961)

published on 18 May 2020

Unissued / Unused material - Hamburg, West Germany (FDR - Federal Republic of Germany). German helicopters are used to carry river boat pilots to where they are needed. Big CU Helicopter pilot talking into mouthpiece. Aerial view from helicopter of boat below. MS as the helicopter comes in and lands on deck of the ship. Various shots as pilot is picked up from lightship and flown off in helicopter. LS From bridge of ship as helicopter flies overhead. CU Small bird sitting on capstan. (f.g....

0

Video How SHIP Navigate Through Ice (Part-2, Conversation With Pilot & Captain)

published on 29 May 2021

This is part -2 (CONVERSATION WITH PILOT AND CAPTAIN) In person Appearing - Captain Thomas Madsen Harbour Pilot, ST. Petersburg Company Credit - WWW.Maersk.com Location - Saint Petersburg, Russia Vessel - Venta Maersk Calender - (JANUARY - APRI), 2021 Music credit - Stock Music Filmora All video was shot on GoPro Hero 9 Edited through Adobe Light Room & Wondershare Filmora If you have not seen the 1st part find the link below How SHIP Navigate Through Ice (Part-1,...

1

Video PilotVessel "SEA MASTER"/ BulkCarrierShip "S SAMBA"/ Recalada KM239_1 RioDeLaPlata / 24.09.2024

published on 30 September 2024

#PilotVessel "SEA MASTER"/ On board #BulkCarrierShip "S SAMBA" #KM239_1 #Recalada #PuntaIndioChannel #RioDeLaPlata #Argentina/ 24th. September 2024 - 09:07 Local Time.- On this video (with original sound), you can watch the Pilot Vessel "SEA MASTER", arrived at #KM239_1 #Recalada #boardingpoint #PuntaIndioChannel to disembark the Rio de la Plata Pilots. This video was filmed on board the following Vessel: Bulk Carrier Ship "S SAMBA" - Call Sign: V7IU6 - IMO Number: 9712486 - Flag: MARSHALL...

0