Article

More details and an analysis of the Ever Given accident


published on 6 October 2021 1398 -

Photo social media

For "Der Spiegel" (a German newspaper), an experienced pilot and ex-captain analysed the accident of the freighter Ever Given, which blocked the Suez Canal for days, on the basis of documents. His conclusion: the captain and pilot made serious mistakes during the passage.

The accident of the freighter Ever Given, which ran into the bank of the Suez Canal on 23 March and blocked the canal, resulted in costs of several hundred million: For six days there was no way through the canal; 400 ships had to put up with expensive waiting times.

A sandstorm
was always cited as the explanation for the incident. But the experienced seaman Gerald Immens (62), a long-time captain of tankers and today an instructor and pilot in the Kiel Canal, has another explanation for the disaster. After analysing publicly available data on the fateful voyage of the Ever Given, he concludes that both the captain of the 400-metre-long ocean liner and the pilot on board made serious mistakes, as he explains in an interview with "Der Spiegel".
Photo social media
Photo social media
Photo social media
Photo social media
Captain made a serious mistake
Gerald Immens considers it "nonsense" that the weather was responsible for the accident. Immensely: "A ship like this even sails in thick fog," he explains. At the time of the accident, there were stormy winds, but they came from behind and did not play a decisive role. However, when the ship entered the canal, it was affected by a considerable crosswind, which reacted sensitively due to the large side area and the thousands of containers on board.

According to the expert, the captain had to compensate for the so-called offset due to the crosswind and correct his course to do so. Since "you can hardly see any water" from the bridge of a huge ship like the Ever Given, the captain and pilot have to rely on GPS data and electronic sea charts for navigation. Immens explains: "Immediately after entering the channel, this AIS data shows a 'heading' of 48 degrees: that is the course the ship is steering - and also the course that could be read from the nautical chart. But over ground, the Ever Given does not keep this course due to the strong crosswinds; she actually only sails around 42 degrees - i.e. towards the left bank of the channel.

Passed through the channel at top speed
So this deviation should have been "added to the course", i.e. the ship should have moved to 54 degrees. But this did not happen for several minutes - according to Immens a "serious navigation error" and an "obvious lack of understanding of the physics of how a ship behaves in such a canal journey". As a result, the Ever Given came closer and closer to the left side of the canal. Then a hydrodynamic effect was added in a fatal way: the mighty mountain of water that the freighter was pushing in front of it pushed the ship to the right at the front, while it was sucked to the left at the back.

In order to compensate for this so-called banking effect, it was decided on the bridge to give more speed, so that the rudder is more strongly impelled and the ship reacts more quickly. "In the short term, this is quite correct," Immens explains. "However, it must not cause the ship to speed up permanently, because then the hydrodynamic effects become much stronger." But this is exactly what happened, he says: Although the maximum speed in the canal is eight knots (just under 15 kilometres per hour), the Ever Given had accelerated to 12.8 knots (22 kilometres per hour).

The ship came away from the left side, but then raced towards the right bank of the canal, whereupon the captain accelerated again - the ship came away again and raced towards the left bank once more. Finally, the giant freighter crashed into the bank at almost 13 knots, whereupon it turned and hit the eastern bank with its stern and became wedged: The Suez Canal was blocked. According to Immens, the accident could only have been avoided if the captain had "done everything possible to reduce speed." But this was not apparent from the data at any time.

"We will never know"
What happened on the bridge between the freighter's entry at 5.10 am and the impact at 5.40 am, Gerald Immens does not know. One thing is certain: a captain is dependent on the pilot, but does not like to give him command. Because the pilot is always on ships he has never sailed before. Immensely: "Imagine you are sitting in an Airbus A380 and the co-pilot says over the loudspeaker: 'I've never flown such a huge thing before and I'm going to try it out today'. You would break out in a sweat." The pilot gives the commands, but the ship's command must "absolutely remain one hundred per cent focused and always pay attention."

After the ship was dredged up in March, Egypt held it until the owners paid a certain sum for the damage. In the settlement, it seems they agreed to keep quiet about who was to blame. And Panama, where the Ever Given is registered, is "not exactly known for in-depth analyses of such incidents." Immensely: "I'm afraid the public will never know what really happened on that bridge."

Join the conversation...

Login or register to write comments and join the discussion!
LV
Louis Vest Houston Pilots, USA
on 10 October 2021, 04:38 UTC

The comparison of the Airbus aviator to a ship's pilot is seriously flawed. Pilots all over the world go through rigorous training under observation and apprenticeship before being sent to navigate in their respective ports. In the port of Houston, my port, a young pilot would not be assigned to such a ship until they had completed three years of training and a gradual increase in assignment size... and most are ship's masters before they begin the training.
1

SP
Sanjeev Pande Ocean Sparkle Limited, India
on 7 October 2021, 14:34 UTC

In my opinion, Capt Gerald Immens presents an opinion, not an analysis. An opinion which is seriously flawed. To say that weather was not responsible i.e. did not play any significant part in causing the incident is amazing for me to accept. Especially from someone said to be an experienced sailor and an trainer of pilots to boot. Further, pilots assume the navigational control of a vessel while the command of the vessel remains with its Captain. Orders given by a pilot are not easily countermanded in the normal course. Only when obvious incompetence is being noticed would any Captain or officer on watch countermand a pilot's order. This is well established by numerous decisions in admiralty law cases. The mistake that was made was the pilots not advising the master to wait till the weather forecast improved or (perhaps) the Captain not asking the pilots their opinion on proceeding to transit despite the poor weather forecast. That too without tug assistance. Once comitted into the canal, the Ever Given was a sitting duck!
5

Read more...

Video Suez canal blocked: attempts continue to free stuck megaship Ever Given

published on 25 March 2021

Efforts to free the giant container ship are continuing after the 400m-long vessel became stuck in the Suez canal. Local authorities attempted to dislodge the 220,000 ton vessel from the banks of the canal using tug boats, but the megaship remains stuck more than one day after it ran aground.

1

Video New Footage Shows Tugboats Trying To Free A Massive Container Ship Blocking The Suez Canal

published on 26 March 2021

New footage shows tugboats trying to free a massive container ship blocking the Suez Canal. MORE INSIDER NEWS VIDEOS: Asian Community Answers 3 Burning Questions On Racism And Stereotypes https://www.youtube.com/watch?v=zF2s_rV4a50 Watch A German Nonprofit Rescue More Than 350 Libyan Migrants In 3 Days https://www.youtube.com/watch?v=mWmUowxX1F0 Watch The Eruption Of Europe’s Most Active Volcano From Every Angle We Could Find https://www.youtube.com/watch?v=AD7HNAC-w94 -----------------------...

0

Video Simulation of EVER GIVEN Accident in Suez Canal 2021 in 3D by FleetMon

published on 27 March 2021

On Mar 23, 2021, at around 0500 UTC, Ultra Large Container Vessel EVER GIVEN ran aground in the Suez Canal north of Suez. The incident caused a blockage of the Suez Canal, extensive vessel traffic jams, and disruptions in the maritime supply chain. Watch a 3D video simulation of the last 90 minutes of her journey before the accident happened. The video is based on AIS vessel position data received by FleetMon.
FleetMon is one of the world’s leading AIS vessel tracking providers offering...

1

Opinion Marine Pilots: Unsung Heroes Of The Shipping Industry

published on 12 August 2020

Qualified pilots are usually employed by the local port or maritime administration, and provide their services to ships for a fee, calculated in relation to the ship’s tonnage, draught or other criteria.

0

Video Look at Life - City of Sailors - Portsmouth - 1965, UK

published on 18 March 2021

Look at Life - City of Sailors - Portsmouth - 1965
Portsmouth is no longer the sea-faring city it once was; this film from the Documentary Series "Look At Life" Volume 5 - Cultural Heritage in 1965 looks at its changing face.

0

Video Look at Life - Icebreakers - Keeping Shipping Routes Open 1966, UK

published on 18 March 2021

Look at Life - Icebreakers - Keeping Shipping Routes Open from 1966
Another of the Look at Life Documentaries - Volume One - Transport - Breaking the Ice - from March 1966 - Taking a look at the Icebreakers responsible for keeping shipping routes open.

0

Video Pilot boat goes out, Pilot Boat comes in. The saltie Cape comes in. Busy Sunday in Duluth!

published on 3 May 2020

I decided to show the typical happenings when a saltwater freighter arrives Duluth. Most of the time they go to anchor and wait for the Elevator dock. The Pilot Boat brings out the Great Lakes Pilot to sail the ship into the port and to the dock. This vessel arrived early Sunday morning, went to anchor until mid afternoon. They are loading grain at the CHS Elevator in Superor.

0

Video SAMIPTA briefing to AMET - safety and innovation in Pilot Ladder.

published on 8 September 2021

AIMPA in association with IMU has organized a Research Paper Competition (SAMIPTA) for cadets of MTI from all disciplines on Pilot ladder risk mitigation and suggest innovative measures to Mitigate risks.

0

Video Pilot Vessel BAYPILOT1 12 2020

published on 31 December 2020

Gross Tonnage:?
Flag:Japan
Home Port:Sumoto
Boat to pick up and drop off pilots

0